ORJ's Rear Brakes

PostPost by: Matt Elan » Mon Apr 20, 2020 1:44 pm

Sorry Moderators - should this be in the Brakes tech section rather than general discussions? if so apologies and feel free to move it.


So, with the lockdown still going and my discovery of the somewhat ineffiecient handbrake on the running Plus 2
I thought I'd refresh the mechanism. Nice and simple job, jack up one side of the car, wheel off and have a little dismantle, clean up the parts reassemble with some new bits and some original parts and some copperslip grease and Bobs your uncle.
So I ordered new tie rods, nuts and clips, new handbrake tie end bushes and a few other odds and sods - unfortunately SJS din't have the clevis pins but hey I thought, it'll be fine at worst a bit of a clean up.

And I thought while I was at it I'd give the lower wishbones and the shock tube a coat of paint as they were a bit rusty. What could possibly go wrong.... - some pictures to follow
Last edited by Matt Elan on Mon Apr 20, 2020 2:16 pm, edited 1 time in total.
Matthew Vale - Classic Motoring Author
1968 Plus 2 - Somewhat cosmetically and mechanically modified
1969 Plus 2S - Currently undergoing nut and bolt restoration
Visit me on matthewvale.com
User avatar
Matt Elan
Fourth Gear
Fourth Gear
 
Posts: 651
Joined: 27 Oct 2011

PostPost by: Matt Elan » Mon Apr 20, 2020 1:59 pm

So after an hour of so I took the LHS caliper off. Why - well take a look at these:
small IMG_3955.jpg and


A nasty rusty mess and note the extra nut on the tie rod

small IMG_3971.jpg and


Another view from above - note the caliper bolt washers are distorted. doh.

small IMG_3972.jpg and


And finally on the bench - the Pivot pins came out easily, using the centralising strip mounting bolt to pull them out - screw in the bolt, grip the head in a vice and gentrly tap the caliper body to draw out the pin, releasing the mechanism. Note the bady corroded clevis pins - more fun to follow....
I also noticed there were no bushes for the hand brake clevis pin on the top of the hand brake lever - lucky i'd ordered two....

And I'll continue on the Brakes section as this will get technical...
Matthew Vale - Classic Motoring Author
1968 Plus 2 - Somewhat cosmetically and mechanically modified
1969 Plus 2S - Currently undergoing nut and bolt restoration
Visit me on matthewvale.com
User avatar
Matt Elan
Fourth Gear
Fourth Gear
 
Posts: 651
Joined: 27 Oct 2011

PostPost by: Matt Elan » Mon Apr 20, 2020 6:36 pm

This now running in the brakes section......
Matthew Vale - Classic Motoring Author
1968 Plus 2 - Somewhat cosmetically and mechanically modified
1969 Plus 2S - Currently undergoing nut and bolt restoration
Visit me on matthewvale.com
User avatar
Matt Elan
Fourth Gear
Fourth Gear
 
Posts: 651
Joined: 27 Oct 2011

Total Online:

Users browsing this forum: No registered users and 28 guests