Anti sizzle stick boot

PostPost by: gjz30075 » Tue Aug 20, 2013 7:29 pm

I've recently put the anti sizzle gearshift stick back on my car, with a new boot, and now find the boot no longer stays attached to the sheet metal plate that gets screwed down to the 'glass. The protrusion of the bushing is simply too big for the boot. Dave Bean says there's only one boot sold nowdays.
Anyone else have this issue? Simple solution is probably make my own boot, but really.....

Greg Z
Greg Z
45/0243K Sprint
45/7286 S3 SE DHC
User avatar
gjz30075
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 3493
Joined: 12 Sep 2003

PostPost by: billwill » Tue Aug 20, 2013 7:32 pm

Make your own new boot out of a piece of leatherette that matches your trims.
Bill Williams

36/6725 S3 Coupe OGU108E Yellow over Black.
billwill
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 5062
Joined: 19 Apr 2008

PostPost by: oldelanman » Wed Aug 21, 2013 6:19 am

You may find it helps to glue the boot to the plate before fitting, fit the plate over not under the insulating felt and don't screw it down too tightly.
Roger
S4 DHC
oldelanman
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 1969
Joined: 02 Jan 2008

PostPost by: jono » Wed Aug 21, 2013 7:11 am

...you're talking about the inner boot I think?

...why not make up a rectangular spacer to lift the whole assembly up slightly?

Jon
jono
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 2025
Joined: 17 May 2007

PostPost by: robertverhey » Wed Aug 21, 2013 7:46 am

S4 isn't it? Seem to recall reading somewhere that a suitably sized cv joint boot can be adapted?
Last edited by robertverhey on Wed Aug 21, 2013 11:50 am, edited 1 time in total.
robertverhey
Fourth Gear
Fourth Gear
 
Posts: 766
Joined: 20 Feb 2007

PostPost by: gjz30075 » Wed Aug 21, 2013 9:04 am

oldelanman wrote:, fit the plate over not under the insulating felt and don't screw it down too tightly.


Aha! this might be my problem. I've always screwed the plate directly down on the 'glass, then put the insulating pad on top. This , of course, pushes the boot down the stick.
Jon, theres only one boot that I know of, but technically called a grommet, per the parts manual.

Worse case, I can adapt a cv boot per Robert's suggestion
Greg Z
45/0243K Sprint
45/7286 S3 SE DHC
User avatar
gjz30075
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 3493
Joined: 12 Sep 2003

PostPost by: jono » Wed Aug 21, 2013 10:53 am

aha...I was speaking as a +2 man..which has an inner and outer boot :oops:
jono
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 2025
Joined: 17 May 2007

PostPost by: gjz30075 » Thu Aug 22, 2013 10:16 am

Jono might have the answer here. Raised the sheet metal a bit and it takes the strain off the boot. It also raises the console a bit too much but the boot stays attached to the sheet metal.

All in all, I think todays repro boots are just too small. It slides around easily on the sheet metal and easily comes 'undone'. A bit more work here but headed in the right direction. I might try to make a piece of sheet metal with a smaller hole to better encapsulate the boot. Thanks to all for the advice.

Greg Z
Attachments
DSC03834.JPG and
DSC03835.JPG and
Greg Z
45/0243K Sprint
45/7286 S3 SE DHC
User avatar
gjz30075
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 3493
Joined: 12 Sep 2003

PostPost by: oldelanman » Thu Aug 22, 2013 3:46 pm

Greg,
Try glueing the boot to the plate - you may not need to make a new plate or use the spacers.
Roger
S4 DHC
oldelanman
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 1969
Joined: 02 Jan 2008

PostPost by: gjz30075 » Thu Aug 22, 2013 5:45 pm

I'll give it a shot, Roger. I'll look for the strongest epoxy for rubber to metal.

Greg z
Greg Z
45/0243K Sprint
45/7286 S3 SE DHC
User avatar
gjz30075
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 3493
Joined: 12 Sep 2003

PostPost by: oldelanman » Thu Aug 22, 2013 7:06 pm

I used RTV sealer - leave it for a good while to go off fully before you fit it to the car. OK so far :wink:
Roger
S4 DHC
oldelanman
Coveted Fifth Gear
Coveted Fifth Gear
 
Posts: 1969
Joined: 02 Jan 2008

Total Online:

Users browsing this forum: No registered users and 17 guests